|# of Units Available||1|
|Deal Type||Outright Sale|
|Estimated New Value||$63,000|
|Manufacturer||Ultrafab Industries Ltd.|
|Fuelled Condition Rating|| B
This is a rating derived by Fuelled via a visual inspection.
|Dimensions||16" x 7'-6"|
|Pressure Rating (PSI)||1480|
|Notes||100 BBL DOUBLE WALLED TANK/SEPARATOR PACKAGE - SWEET
100 BBL Double Walled Tank Includes:
???? All steel tanks (3/16” plate inner and outer tank) tested to 16 oz.
???? 3" truck out c/w 3" valve, piping and Camlok.
???? 24" round manway located on the roof of tank.
???? Internal leak monitor plus drain valve.
???? 8” Wenco thief hatch 0.4 oz vac/16 oz pressure.
???? 6" flanged roof vent.
???? Ladder with safety hoop.
???? 425 gallon internal methanol tank (located inside the inner tank – thus triple contained).
???? Hawk-eye standard gauge board assembly.
???? Truck out ground cable sign.
???? High level shutdown consisting of pneumatic Wellmark switch to shut off vessel level controller.
???? Insulation is applied between the walls of the tanks, high density foam insulation applied to the bottom of the skid.
???? 8" Wide Flange skid with pick-up throat at each end, and 3 lifting lugs on top of tank.
???? 8’ x 10’ Pre-painted aluminum building. One 3’ x 7’ man door, Glazed IWG window and panic hardware and one 36” x 36” sliding window. Building color; tan exterior and white interior.
???? One (1) 24,000 BTU catalytic heater c/w vent hood, thermostat, regulator, safety shut-off and 25’ battery cable leads.
???? Tank, skid, vessels and piping to be sand blasted and painted 2 coats Cloverdale DTM tan.
???? Spill box.
Separator Package Includes:
???? 16" x 7' Three (3) phase separator 1440 psig, registered in Alberta, British Columbia, and Saskatchewan - 1/16” corrosion allowance 10% X-Ray, sweet service.
???? 2" 1500# RTJ welded gas inlet piping.
???? 2" 600# ANSI welded gas outlet piping.
???? 2” 1500# RTJ CVS inlet control valve c/w CVS 4150 pressure controller.
???? 2” 600# RF CVS outlet control valve c/w CVS 4150 pressure controller.
???? 1” Taylor PSV on vessel set at 1440 PSI.
???? 2" Daniels Simplex meter run AGA 2000 - third party complaint c/w 2” 600# FP isolation valve.
???? 1’ Water leg c/w Norriseal 1001A level controller, 1" Norriseal 2275 control valve, Daniels reflex level gauge, bypass piping and 1” additional line to outside of building.
???? Third phase piping c/w Norriseal 1001A level controller, 1” 2275 Norriseal control valve, Daniels transparent level gauge, 1” Nuflo turbine meter c/w bypass piping and prover connections.
???? Fisher 4660 HI/Low pressure pilot.
???? 6 X 30” fuel gas scrubber c/w regulator, PSV and HLSD.
???? 2 - CVS Model 5112 chemical pumps, ½” plungers, PSV’S, rate gauge, stand and drip tray.
???? Vent all regulators and diaphragms outside.
???? 5 valve Manifold for Zed-I system.
???? Install customer supplied Zed-I system and liquid meter totalizer.
Ultrafab separator (16"x7'6"x1480 psi)/100bbl tank & building Jun-08 828054 585310 2008 purchased new, 3 phased
Near worlsey Alberta
|Equipment Still in Operation||No|
|When was equipment last run|
|Does the skid have skirting that needs to be removed||N/A|
|Equipment still connected to piping||N/A|
|Equipment still welded down to piles||N/A|
|Equipment on a gravel pad||N/A|
|Electrical still connected to the equipment||N/A|
|Have vessels been cleaned out||Unknown
|Hours since last major service? If so, how many?|
|Has equipment been preserved? If so, when?||N/A|
|Equipment accessibility in yard or work site|
|Access into work site|
|Any road use agreement to access site||N/A|
|Provincial Vessel Registrations||AB, BC, SK|
|Overall cleanliness of package|
|Operator Notes/Interview/Other Comments|
|Nice looking package|
Log in to contact seller